Electric power steering
Where to find us
Brands we work with
Problem: In the case of a critical discharge of a low-voltage battery (12–48 V), the electronics prevent charging because it is dangerous with Li-Ion batteries. The manufacturer recommends discarding fully functional batteries and replacing them with new ones. This is expensive.
Problem: We received an electric car with very discharged traction batteries. The problem is typical for the Fiat 500. During idle time, the batteries discharged below the permissible level, and the car's electric motor stopped starting.
Problem: In the case of a critical discharge of a low-voltage battery (12–48 V), the electronics prevent charging because it is dangerous with Li-Ion batteries. The manufacturer recommends discarding fully functional batteries and replacing them with new ones. This is expensive.
Problem: Failure of Toyota hybrid batteries is a common problem that our customers come to us with. The battery cells degrade, making it impossible for the car to operate normally.
Problem: Land Rover Range Rover Sport 3.0 SDV6 Hybrid AT AWD - the hybrid system did not work, the VBB was in emergency mode. The car was running only on diesel fuel, the low-voltage battery was not charging.
Problem: None of the car's systems were working at all, it wasn't even possible to raise it on a lift because the air suspension didn't activate either. I had to install the Porsche near the repair box on "goat" stands.
Problem: Errors P0AA6, P1F0E - high voltage charging system service
Problem: The problem with the car was the incompatibility of the Chinese GB/T standard charging system with European charging stations. This created difficulties for the owner of the Audi Q4 e-tron, since the car, produced for the Chinese market, could not charge at European stations with the required speed and reliability.
Problem: Failure of Toyota hybrid batteries is a common problem that our customers come to us with. The battery cells degrade, making it impossible for the car to operate normally.
Problem: We received an electric car with very discharged traction batteries. The problem is typical for the Fiat 500. During idle time, the batteries discharged below the permissible level, and the car's electric motor stopped starting.
Problem: The Hyundai Kona made a rather loud noise. The customer diagnosed the malfunction on his own - in his opinion, the gearbox was the cause of the extraneous sounds.
Problem: There was water and rust inside the rail, which damaged both the needle bearing in the cover and the torque sensor, i.e. both the mechanical and electrical parts
Problem: The client complained about a knock at the bottom – it was as if a gnome was sitting there with a hammer and hitting plastic with it. However, the dwarf did not always do this, mainly after an energetic ride. Then, the sound could disappear and reappear with a new sharp push on the pedal.
Problem: Destruction (wear) of differential satellites and, as a consequence, noises (hum) when driving the vehicle.
Problem: Steering rack leakage from under the tie rod dust cover
Problem: Steering rack leakage from under the tie rod dust cover
Problem: The owner of a Citroen C4 Picasso car came to us with a complaint about poor engine performance. The car literally could hardly drive: the engine would not rev above 2000 rpm and did not develop the necessary power. Fuel consumption increased significantly. The problem lies in the car's clogged particulate filter.
Problem: We were approached by the owner of a 2017 Citroen Berlingo with complaints of a knocking steering rack.
Problem: We were approached by the owner of a 2017 Citroen Berlingo with complaints of a knocking steering rack.
Problem: The 48V starter/generator on the Audi A6 would not give a charge
